Product ID:SPECIALLY DENATUREATED ALCOHOL 3A, 200 PROOF
MSDS Date:01/01/1991
FSC:6810
NIIN:00-543-7415
MSDS Number: BMXHJ

AAPER ALCOHOL AND CHEMICAL CO.

11 ISAAC SHELBY DRIVE
SHELBYVILLE, KY 40065-8814
US

Emergency Phone: 502-633-0650

Info Phone: 502-633-0650

Cage: 61305

AAPER ALCOHOL AND CHEMICAL CO

339 SHELBYVILLE, KY 40066-0339 US

Telephone: 502-633-0650

Cage: 61305

ETHYL ALCOHOL (FLAMMABLE/NERVOUS SYSTEM DEPRESSANT)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 95.2%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

METHYL ALCOHOL

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 4.8%

OSHA PEL 260 MG/M3;200 PPM

ACGIH TLV: 262 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHAL: EXPOSURE TO OVER 1000 PPM MAY
CAUSE HEADACHE, DROWSINESS AND LASSITUDE, APPETITE LOSS, &
INABILITY TO CONCENTRATE. IRRIT OF THROAT. INGEST: CAN CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION, NAUSEA, VOMITING, DIARRHEA.
EYE: LIQ/VAPOR MAY CAUSE IRRIT. SKIN: MAY CAUSE IRRIT & DEFATTING
OF SKIN ON PROLONGED CONTACT.

First Aid:INGEST: IF CONSCIOUS/ABLE TO SWALLOW, GIVE MILK/WATER TO
DRINK (DILUTE). NEVER GIVE ANYTHING BY MOUTH TO
UNCONSCIOUS/CONVULSING PERSON. CALL DR/CHEMTREC IMMED. INDUCE VOMIT
ONLY IF ADVISED BY DR/CHEMT REC. INHAL: IMMED REMOVE TO FRESH AIR.
IF BREATHING STOPPED, GIVE ARTIF RESP, PREFER MOUTH-TO-MOUTH. GET
MED AID IMMED. CONTACT W/EYE/SKIN: IMMED FLUSH W/COOL WTR. FLUSH
EYE 15 MIN. GET MED AID IMMED.

Flash Point Method:TCC
Flash Point:50.0F,10.0C
Lower Limits:3.3
Upper Limits:19
Extinguishing Media:DRY CHEMICAL, ALCOHOL FOAM, CARBON DIOXIDE; WATER
MAY BE INEFFECTIVE, BUT MAY BE USED TO KEEP FIRE EXPOSED CNTNR
COOL.
Fire Fighting Procedures:IF LEAK OR SPILL HAS NOT IGNITED, DISPERSE
VAPOR W/WATER SPRAY & PROTECT MEN ATTEMPTING TO STOP LEAK. WATER
MAY BE USED TO FLUSH SPILL/DILUTE TO NONFLAMMABLE.
Unusual Fire/Explosion Hazard:FIREFIGHTERS SHOULD WEAR SCBA IN POSITIVE
PRESSURE MODE W/FULL FACE PIECE WHEN THERE IS A POSSIBILITY OF
EXPOSURE TO SMOKE, FUMES OR HAZARDOUS DECOMP PROUCTS.

Spill Release Procedures:WEAR RESP PROTECTION & PROTECTIVE CLOTHING.
CONTAIN SPILLED MATERIAL. TRANSFER TO SECURE CONTAINERS. WHERE
NECESSARY, COLLECT USING ABSORBENT MEDIA. REPORT RELEASE IF
QUANTITY IS REPORTABLE UNDER APPL ICABLE LAWS & REGULATIONS.

Handling and Storage Precautions:PROTECT CONTAINER AGAINST PHYSICAL
DAMAGE. DETACHED OR OUTSIDE STORAGE IS PREFERRED. INSIDE STORAGE
SHOULD BE IN A NFPA FLAMM LIQ STORAGE RM/CABINET.
Other Precautions:ELIMINATE IGNIT SOURCES. SMOKING PROHIBITED IN
STORAGE AREAS. ELEC INSTALLATION SHOULD BE IN ACCORD W/ARTICLE 501
(NAT'L ELEC CODE). FOLLOW NFPA 30, FLAMM/COMBUST LIQ
CODE--STORAGE/HANDLING. MAKE FREQ UENT LEAKAGE INSPECTIONS. *

Respiratory Protection:WHERE EXPOSURE IS LIKELY TO EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA REPIRATORY PROTECTION EQUIPMENT.
RESPIRATORS SHOULD BE SELECTED BASED ON THE FORM & CONCENTRATION OF
CONTAMINANAT IN AIR & IN ACC ORDANCE W/OSHA 29 CFR 1910.134.
Ventilation:HANDLE IN THE PRESENCE OF ADEQUATE VENTILATION.
Protective Gloves:WEAR IMPERVIOUS GLOVES
Eye Protection:SAFETY GLASSES (ANSI Z87.1)(POS CONTACT)
Other Protective Equipment:WEAR PROTECT CLOTH IMPERVIOUS TO PRODUCT FOR
DURATION OF ANTICIPATED EXPOS IF THERE IS POTENTIAL/REPEATED SKIN
CONTACT.
Work Hygienic Practices:N/K * KEEP FROM HEAT/SUN. OPEN W/CARE. CLOSE
AFTER USE. CNTNR HAZARDOUS WHEN EMPTY. SINCE EMPTIED CNTNR RETAIN
**
Supplemental Safety and Health
** RESIDUE, OBSERVE PRECAUTIONS. PROVIDE AUTO SPRINKLER SYS. ISOLATE
FROM OXIDIZERS, CHEM CAPABLE OF SPONTANEOUS HEATING, MAT'LS REACT
W/AIR/MOISTURE TO LIBERATE HEAT, IGNIT SOURCES/EXPLOSIVES. CONSUL T
LOCAL FIRE CODES. BOND/GRND METAL CNTNR WHEN CONTENTS TRANSFERED.
NEVER USE PRESSURE TO EMPTY. NOT FOR HOUSEHOLD USE.

HCC:F2
Boiling Pt:B.P. Text:173F,78C
Melt/Freeze Pt:M.P/F.P Text:-173F,-114C
Vapor Pres:44.6 @ 60F
Vapor Density:1.59
Spec Gravity:0.7981 @ 60 F
Solubility in Water:COMPLETE.
Appearance and Odor:CLEAR AND COLORLESS.

Stability Indicator/Materials to Avoid:YES
CONTACT WITH ACETYL CHLORIDE AND A WIDE RANGE OF OXIDIZING AGENTS MAY
REACT VIOLENTLY.

Waste Disposal Methods:ALL RECOVERED MATERIAL SHOULD BE PACKAGED,
LABLED, TRANSPORTED, AND DISPOSED OF, OR RECLAIMED IN CONFORMANCE
WITH APPLICABLE LAWS AND REGULATIONS AND IN CONFORMANCE WITH GOOD
ENGINEERING PRACTICES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.